Product ID:ENAMEL G-2252
MSDS Date:05/04/1990
FSC:8010
NIIN:00-285-4908
MSDS Number: BPTYN

Emergency Phone: 216-773-8911

Info Phone: 216-773-8911

Cage: 70228

Telephone: 216-773-8911

Cage: 70228

ALIPHATIC PETRO.DISTILLATES (VAPOR PRESSURE 2 MM HG)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 5-20%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE REDNESS, IRRITATION,
SWELLING AND BLURRED VISION. SKIN: PROLONGED OR REPEATED CONTACT
CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS. BREATHING:
EXCESSIVE INHALATION OF VAPORS AN D/OR SPRAY MIST CAN CAUSE
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, UNCONSCIOUSNESS
Effects of Overexposure:AND EVEN ASPHYXIATION. SWALLOWING: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA;
ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.

First Aid:EYES:FLUSH W/WATER 15 MINS.LIFT EYELIDS,GET PROMPT MED
AID.SKIN:WASH W/SOAP & WTR,RMV CONTAM CLOTH PROMPTLY.SEE DR IF
IRRIT PERSISTS.INGEST:DONT INDUCE VOMIT.KEEP WARM,QUIET.GET MED
AID. ASPIRATION IN TO LUNGS CAN CAUSE CHEM PNEUMONITIS(CANBE
FATAL).DRINK 1-2 GLASSES WTR(DILUTE).INHAL:MOVE TO FRESH AIR.IF
BREATH STOPPED/DIFFICULT, GIVE ARTIF RESP/OXYGEN AS NEEDED.KEEP
WARM,QUIET,GET MED AID.SEE

Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:0.70
Upper Limits:7.00
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR, TRAVEL ALONG GRND
TO IGNIT SOURCE. NEVER CUT TORCH ON EMPTY CNTNR. APPLIC TO HOT
SRFCS REQ CAUTIONS. OVEREXPOS TO DECOMP PROD-HEALTH HZD

Spill Release Procedures:SMALL: ABSORB LIQ W/RAGS, FLOOR ABSORBENT,
VERMICULITE/ETC. TRANSFER TO HOOD.LRG:ELIMINATE IGNIT SOURCES.DIKE
SPILL. VENT AREA IF INDOORS,PUMP LIQ TO SALV TANK.TAKE UP REMAINING
LIQ W/SAND, FLOOR ABSO RB, ETC.SHOVEL INTO CNTNR.PREVENT RUNOFF TO
SEWER,
Neutralizing Agent:N/K WATERBODIES. NOTIFY AUTHORITIES AS REQ'D BY
LOCAL, STATE & FED REGS.

Handling and Storage Precautions:DONT DROP CONTAINERS. AVOID HEAT,
SPARKS & OPEN FLAME. STORE LRG QTY IN BLDGS IN COMPLY W/OSHA
1910.106. DONT USE PRESSURE TO EMPTY.
Other Precautions:AVOID BREATHING SANDING DUST. DONT HANDLE TILL MFR'S
PRECAUTIONS READ/UNDERSTOOD.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS WITH UNRESTRICTED VENT
APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE A
COMBINATION OF PARTICULATES & VAPOR. IN CONFINED AREAS, APPROVED
AIR LINE TYPE RESPIRATOR OR H OODS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
AIR CONTAMINANT CONCENTRATION BELOW CURRENT PEL/TLV AND
Protective Gloves:WEAR RESISTANT GLOVES (NITRILE RUBBER)
Eye Protection:CHEM SPLSH GOGGLES ADVISED, SFTY GLASSES
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VOLATILES BELOW LEL. REMOVE HEAVY SOLVENT VAPORS FROM LOWER LEVELS OF
AREA. ELIMINATE IGNITION SOURCES (NON- EXPLOSION PROOF EQUIP) IF
FLAMMABLE MIXTURES WILL BE ENCOUNTERED. REMOVE DECOMPOSITION PROD
UCTS FORMED DURING WELDING/FLAME CUT OFCOATED SURFACES. BAKING
FINISHES-VENT VAPORS EMITTED ON HEATING.

HCC:F4
Boiling Pt:B.P. Text:281 TO 400F
Vapor Density:> AIR
Spec Gravity:1.2473
Evaporation Rate & Reference:0.06 X N-BUTYL ACETATE
Appearance and Odor:BROWN LIQUID
Percent Volatiles by Volume:51.2

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID).
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE,
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.